Product ID:CASTALL E-463 PART A
MSDS Date:01/03/1991
FSC:4940
NIIN:01-396-5209
Kit Part:Y
MSDS Number: BYPGS

CASTALL INC

E WEYMOUTH INDUSTRIAL PK PLEASANT ST
EAST WEYMOUTH, MA 02189-1699
US

Emergency Phone: 617-337-6075

Info Phone: 617-337-6075

Preparer: ROBERT DAVIDS

Cage: DO809

CASTALL INC EAST WEYMOUTH INDUSTRIAL PARK

EAST WEYMOUTH, MA 02189-1699 US

Telephone: 617-337-6075

Cage: 29966

EPICHLOROHYDRIN, CHLOROMETHYLOXIRANE (ANIMAL CARCINOGEN BY

CAS: 106-89-8

RTECS: TX4900000

Fraction By Weight: <0.1%

OSHA PEL 5 PPM (SKIN) TWA

ACGIH TLV: 0.38 MG/CUM IC (A2)

EPA Report Quantity: 100 LBS

DOT Report Quantity: 100 LBS

Routes of Entry: Inhalation:NO Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:NOT ESTABLISHED AS OF THE CURRENT
ISSUE DATE.
Explanation of Carcinogenicity:SEE INGREDIENTS
Effects of Overexposure:NOT ESTABLISHED AS OF THE CURRENT ISSUE DATE.

First Aid:EYES: FLUSH W/WATER FOR 15 MINS. SKIN: REMOVE THE UNCURED
PRODUCT W/A DRY CLOTH/TOWEL, WASH THOROUGHLY W/SOAP & WATER. DON'T
USE A SOLVENT TO REMOVE PRODUCT. INHALATION: REMOVE TO FRESH AIR
IMMEDIATEL Y. INGESTION: GIVE MILK/WHITE OF EGG BEATEN W/WATER &
REPEAT UNTIL VOMIT FLUID IS CLEAR. IF VOMITING DOESN'T OCCUR,
INDUCE VOMITING.

Flash Point Method:COC
Flash Point:450F
Extinguishing Media:SAND, FOAM, CO, DRY CHEMICALS
Fire Fighting Procedures:WEAR FULL PROTECTIVE CLOTHING INCLUDING A
SCBA. DON'T USE FOAM ON FIRES REVOLVING ELECTRIAL EQUIPMENT.
Unusual Fire/Explosion Hazard:DURING A FIRE, IRRITATING &/TOXIC GASES
MAY BE PRESENT FROM THE DECOMPOSITION/COMBUSTION PRODUCTS.

Spill Release Procedures:COVER W/DRY ABSORBENT MATERIAL SUCH AS
SAND/SAWDUST. SCOOP UP & PLACE IN AN APPROPRIATE CONTAINER.

Handling and Storage Precautions:STORE AT AMBIENT TEMPS/80F. AVERAGE
SHELF LIFE IS TWELVE MONTHS IN ORIGINAL SEALED CONTAINERS. KEEP
FROM MOISTURE & EXCESSIVE HEAT.
Other Precautions:STORE IN DRY AREA AWAY FROM EXCESSIVE HEAT.

Respiratory Protection:NONE REQUIRED UNLESS VAPOR CONCENTRATIONS ARE
EXCESSIVE. A NIOSH APPROVED ORGANIC VAPOR CARTRIDGE RESPIRATOR CAN
BE USED. OBSERVE THE MANUFACTURERS DIRECTIONS CONCERNING THE USE OF
RESPIRATORY PROTECT ION.
Ventilation:NO SPECIAL REQUIREMENTS. ENCLOSED/POORLY VENTILATED AREAS:
USE LOCAL EXHAUST/DILUTION VENTILATION.
Protective Gloves:PLASTIC/RUBBER
Eye Protection:NONE NORMALLY REQUIRED.
Other Protective Equipment:WHERE APPLYING TO OVERHEAD SURFACES SAFETY
GLASSES ARE REQUIRED.
Supplemental Safety and Health
FIRST AID CONT'D: DON'T INDUCE VOMITING/GIVING ANYTHING BY MOUTH TO AN
UNCONSCIOUS PERSON. OBTAIN MEDICAL ATTENTION IN ALL CASES.

Spec Gravity:0.8
Solubility in Water:INSOLUBLE
Appearance and Odor:BLACK VISCOUS LIQUID, ESSENTIALLY ODORLESS
Percent Volatiles by Volume:0.1

Stability Indicator/Materials to Avoid:YES
ACIDIC/BASIC OXIDIZING AGENTS, WATER
Stability Condition to Avoid:EXCESSIVE HEAT, MOISTURE

Waste Disposal Methods:LANDFILL/INCINERATE UNDER CONDITIONS WHICH MEET
FEDERAL, STATE & LOCAL REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.